Rolling Hills Generating seeks permits for Ohio uprate project

Rolling Hills Generating Facility Ohio U.S> Army Corps of Engineers simple-cycle conversion combined-cycle natural gas-fired power plant Siemens turbine generators

The U.S. Army Corps of Engineers is taking comment until July 8 on a Clean Water Act application from Rolling Hills Generating LLC related to a planned conversion of a simple-cycle power plant into a combined-cycle facility.

The Rolling Hills Generating Facility is located north of the Village of Wilkesville in Vinton County, Ohio. The upgrade project would involve construction of two water lines in a single right-of-way corridor from that location to the southeast and terminating at the Ohio River in Meigs County, Ohio. The project proposes a water intake structure on the Right Bank at Ohio River Mile Point 255.1.

“The applicant is proposing to convert the current Rolling Hills Generating Facility from a simple cycle electric generating facility to a combined cycle electric generating facility,” said a Corps notice. “The current generating facility utilizes a simple cycle combustion process via five natural gas fired combustion turbines. The conversion would require expansion and redevelopment of the current generating facility, adding four heat recovery steam generators and two steam generators to four of the combustion turbines. One combustion turbine would remain as a simple cycle unit.”

The converted generating facility would require outfall and intake structures at the Ohio River. Installation of a pump station and access road near the outfall and intake structures would not fill any waters of the U.S. Installation of the intake structure would require dredging and placement of rip-rap and would permanently fill approximately 0.12 acres below the ordinary high water mark of the Ohio River to an average depth of 2.0 feet. Annual maintenance dredging at the intake structure would be required to an average depth of 5.0 feet.

This conversion project would permanently fill six wetlands totaling 0.67 acres, a 0.014 acre pond, and six ephemeral streams totaling 1,928 linear feet at the Rolling Hills Generating Facility site. These streams and wetlands are currently located just outside the power block fence line and would be permanently filled to accommodate the expanded footprint required for the conversion.

In May 2013, the Ohio Power Siting Board authorized Rolling Hills Generating to increase the capacity of its existing natural gas-fired facility in Wilkesville from 860 MW to 1,414 MW. The proposed conversion was estimated at that point to cost $865m and would result in a combined-cycle natural gas-fueled generating facility with a capacity of 1,414 MW.

Conversion of the plant would use all five of the existing Siemens 501FD2 natural gas-fired combustion turbine generators. One combustion turbine would remain in simple-cycle configuration with a nominal output of 172 MW. Four of the five combustion turbines would be coupled to Heat Recovery Steam Generators and each would be equipped with 550 million British thermal units per hour (MMBtu/hour) duct burners. Each pair of gas combustion turbines would be combined with HRSGs and a steam turbine generator set to create 2x1 power blocks, each with a nominal output of approximately 621 MW.

This company is affiliated with Tenaska Capital Management LLC.

This article was republished with permission from GenerationHub.

2014 Articles

Harvard Law School professor pays Clean Power Plan is unconstitutional

12/31/2014

Laurence H. Tribe, professor of constitutional law at Harvard University and former mentor to Barack Obama, said in an article last week that the EPA’s Clean Power Plan is unconstitutional.

3 SKorea workers die at nuke plant construction site

12/30/2014

SEOUL, South Korea (AP) — Three South Korean workers died Friday after apparently inhaling toxic gas at a construction site for a nuclear plant being built by South Korea's monopoly nuclear power company, which has come un...

UMaine in business of certifying turbine blades

12/30/2014

ORONO, Maine (AP) — The University of Maine has tested its largest wind turbine blade to date. UMaine's Advanced Structures and Composites Center completed static strength testing this month of a 184-foot-long wind turbine...

Mergers, EPA carbon plan generated much attention during 2014

12/29/2014

Mergers, the Environmental Protection Agency (EPA) Clean Power Plan, cheap natural gas and the polar vortex were among the most noteworthy generation stories of 2014.

Developer opens Ohio review for 800-MW, gas-fired project

12/29/2014

Clean Energy Future-Lordstown LLC plans an 800-MW, gas-fired power project, and on Dec. 24 applied with the Ohio Power Siting Board for certain routine waivers it needs before filing a full siting application for this proj...

New England utility exec named to Vermont PSB

12/29/2014

A woman who worked for Vermont's Department of Public Service for 17 years is going to become the next member of the utility-regulating Public Service Board. The appointment of Sarah Hofmann was announced Monday by Gov. Pe...

Brown picks aide to lead troubled California utility board

12/29/2014

Gov. Jerry Brown named a former adviser on Tuesday to be the next head of California's troubled utilities commission, replacing a regulatory chief accused of back-channel dealings with utilities. Michael Picker, a former a...

Washington state carbon emissions dropped in 2011

12/29/2014

Greenhouse gas emissions in Washington state dropped by about 4.6 percent between 2010 and 2011, led by reductions in emissions from the electricity sector, according to the latest figures released by the state. The latest...

Group wants state regulators recused from PNM case

12/29/2014

State regulators in less than two weeks are to begin deliberating a proposal that calls for shutting down part of an aging coal-fired power plant in northwestern New Mexico that serves more than 2 million customers in the ...

Vermont Yankee plant prepares to shut down

12/29/2014

The Vermont Yankee nuclear plant is getting ready to shut down. Its owner, Entergy Corp., says it is closing the plant for economic reasons. The plant in Vernon is expected to disconnect from the regional power grid Monday.

PSEG Solar to acquire Maryland solar project from juwi

12/23/2014

PSEG Solar Source will acquire a 12.9-MW solar energy facility near Waldorf, Maryland from juwi solar (JSI). The PSEG Waldorf Solar Energy Center will increase the capacity of PSEG Solar Source's portfolio to 123-MW.

PG&E discloses more emails with state regulators

12/23/2014

California's largest power utility released a dozen more emails Monday that it said showed improper back-channel discussions between the utility and top state regulators.

Indianapolis airport solar farm expansion completed

12/23/2014

Contractors have finished bringing online dozens of acres of solar panels at Indianapolis International Airport, solidifying its status as the home of the nation's largest airport-based solar farm.

French power company to pay $772M in bribery case

12/23/2014

A French power and transportation company has agreed to pay $772 million to resolve allegations that it bribed high-ranking foreign government officials for lucrative projects, the Justice Department said Monday.

Nebraska nuclear plant back online after short outage

12/23/2014

The Fort Calhoun nuclear power plant is back online less than a week after its main generator unexpectedly shut down as a precaution.

Ameren Missouri plans $135M in energy efficiency

12/23/2014

Missouri's largest electric company said Monday that it plans to invest $135 million in energy efficiency programs for customers over a three-year period.

TEPCO completes nuclear fuel assemblies removal from Fukushima 4

12/22/2014

Tokyo Electric Power Co. (TEPCO) said it has safely removed the fuel assemblies from the most damaged nuclear reactor at the Fukushima Daiichi nuclear power plant.

B&W Vølund to build waste-to-energy power plant in Scotland

12/22/2014

In a consortium with Interserve, Babcock & Wilcox Co.’s (B&W, NYSE:BWC) subsidiary, Babcock & Wilcox Vølund A/S (B&W Vølund), will engineer, procure and construct (EPC) a waste-to-energy (WTE) power plant f...

SKorea holds N-plant drills against cyber threats

12/22/2014

South Korea's monopoly nuclear power company said it began drills Monday against possible cyberattacks after online threats of attack against its plants.

PSC approves solar power project

12/22/2014

The Public Service Commission has approved solar power project planned by Kentucky Utilities and Louisville Gas and Electric in Mercer County.

Did You Like this Article? Get All the Energy Industry News Delivered to Your Inbox

Subscribe to an email newsletter today at no cost and receive the latest news and information.

 Subscribe Now

Whitepapers

Maximizing Operational Excellence

In a recent survey conducted by PennEnergy Research, 70% of surveyed energy industry professional...

Leveraging the Power of Information in the Energy Industry

Information Governance is about more than compliance. It’s about using your information to drive ...

Reduce Engineering Project Complexity

Engineering document management presents unique and complex challenges. A solution based in Enter...

Revolutionizing Asset Management in the Electric Power Industry

With the arrival of the Industrial Internet of Things, data is growing and becoming more accessib...